Regulator for Arctic Cat 400 Bearcat 500 Triumph TT600 America Bonneville Thruxton 900 Scrambler Speedmaster 1996-2020

CAD$ 154.00
Availability: In stock
SKU
RM30405

Please note that there are multiple regulators for some Triumph vehicles. Please refer to the note below to make sur you purchase the right part.



Bonneville 2017 to 2020: This part will only fit on Bonneville with a VIN HIGHER than 513325. If you have a LOWER VIN you should look for parts # RM30506 / RM30506H / RMS022-105928 / RMS023 106203 / RMS023-107140.



Thruxton from 2008 to 2020 This part will only fit Thruxton with a VIN HIGHER than 513322. If your vehicle has a VIN inferior to 513321, refer to OEM T1300890.



Please always compare your original part to our photos, before purchasing.

Battery condition is extremely important. No voltage regulator can work correctly with a bad or weak battery. Always fully charge your battery before performing any charging system tests or replacing parts. If there is any doubt, have the battery load tested or replaced.

3430-016
3430-037
T1300819
3430-072
T1300888
T1300889
T1300890

Dimensions :
Width : 80mm
Length : 115mm
Height: 54mm
Fixation holes center to center : 80mm
Wires length: 275mm

Other specifications :
Number of plugs : 1
Number of pins : 5
Minimum Charging Voltage: 14.5V +/- 0.5V
Maximum Charging Current: 25A-35A/300W-500W
Open Circuit Voltage: <15V
Operation Temperature: -20⁰ to 85⁰

BEWARE: Arctic Cat split the year on certain models; the RM30405 replaces OEM parts #3430-037 and #3430-016

The 1996 and early-1997 454 Bearcat 4x4 has a different plug. You need to install the harness-side included connector on your vehicule. Please following the color code supplied at the end of this page.

Color code for 1996 and early-1997 454 Bearcat 4x4 harness-side connector :
The 3 Black wires to the 3 Yellow's
Black/Red to Red
Black/White to Green

This is the 1996 and early-1997 harness plug :

Before installing your new regulator/rectifier:

  • Check the AC output of the stator.
  • Replace any burned or corroded connectors on stator and regulator/rectifier
  • Check and repair any melted wiring.
  • Use hi-temp dielectric grease on all connectors.

Brand new voltage regulator rectifier

BEWARE : 1996 and early 1997 454 Bearcat 4x4 has a different plug : Please consult installation instruction before buying this product

  • Direct replacement to your original unit.
  • Plug-and-play, direct fit, easy installation.
  • No assembly required
  • The Quality exceeds the OEM equipment
  • Improved heat sink and charging capabilities
  • Higher grade of electric components.
  • All products shipped are tested

Beware, Arctic Cat split the year on certain models; the RM30405 replaces OEM parts #3430-037 and #3430-016.

*All item pictures are accurate, if in doubt do not hesitate and compare our item to your original part.

Write Your Own Review
You're reviewing:Regulator for Arctic Cat 400 Bearcat 500 Triumph TT600 America Bonneville Thruxton 900 Scrambler Speedmaster 1996-2020
Your Rating
Customers Also Viewed
Currently there is no product to display.