Kit Generator Stator + Mosfet Voltage Regulator Rectifier for Polaris Sportsman 325 ETX / 450 HO / 570 X2 2014-2020

CAD$ 372.00
Availability: In stock
SKU
RMS900-106009
106009-R00

Generator Stator Dimensions
Interior diameter : 54 mm
Exterior diameter : 126 mm
Thickness : 19 mm
Length of wires stator to grommet : 85 mm
Length of wires grommet to plug : 290 mm

Other specifications :
Number of wires : 3
Number of plugs : 1
Number of pins : 3

Wire to wire resistance :
Alternator : Black between each Black = 0.4 ohms +/-20%

Mosfet Voltage Regulator Rectifier Dimensions
Width : 50 mm
Length : 112 mm
Height : 108 mm
Fixation holes center to center : 84 mm
Wires Length: 600 mm & 1200 mm

Other specifications :
Number of plugs : 3
Number of pins : 5
Number of wires: 5
Minimum Charging Voltage: 14.5 V +/- 0.5 V
Maximum Charging Current: 50 A / 500 W
Open Circuit Voltage: 15 V
Operation Temperature: -20⁰ to 85⁰

Before installing your new stator

  • Check the AC output of the stator.
  • Replace any burned or corroded connectors on stator and regulator/rectifier
  • Check and repair any melted wiring.
  • Use hi-temp dielectric grease on all connectors

Before installing your new voltage regulator rectifier;

  • Check the AC output of the stator.
  • Replace any burned or corroded connectors on stator and regulator/rectifier
  • Check and repair any melted wiring.
  • Use hi-temp dielectric grease on all connectors.

Brand New aftermarket Stator + Mosfet Voltage Regulator Rectifier Kit

  • Direct replacement to your original unit
  • All product shipped are tested

Generator Stator:

Brand new aftermarket generator stator

  • Plug-and-play, direct fit, easy installation
  • Highest grade of of lamination materials
  • Highest grade of of copper winding, resistant to 200 degrees Celsius
  • Connector included
  • Rubber grommet included

We have even included the opposite connector (main harness side), as we know these are often melted corroded defective and a major cause for repetitive electrical issues.

All item pictures are accurate; if in doubt, do not hesitate to compare our item to your original part.

When using this stator on 2016-2018 Polaris Sportsman 570 models, please pay close attention to the stator and regulator wiring harness routing. The OEM wire routing was very poor, and allowed the harness to rub against the motor, damaging the insulation and damaging the charging system. We recommend routing your stator/regulator wiring outside of the frame rail, and securing the harness to the frame with zip ties. This should prevent any future damage to the wiring harness.

Battery condition is extremely important. No stator can work correctly with a bad or weak battery. Always fully charge your battery before performing any charging system tests or replacing parts. If there is any doubt, have the battery load tested or replaced.

Please Note: There are two possible stators for the RZR XP 900 and RZR 4 XP 900 models. This stator fits models built 3/16/12 and after (OEM # 4013013, stator thickness 19 mm). For the stator built 3/15/12 and before, the right part is RM01205 (OEM # 4013224, stator thickness 27 mm). Always check in the 'Fits models' section and please compare to your original part before buying.

Brand new Mosfet voltage regulator rectifier

Mosfet Voltage Regulator

  • The quality exceeds the OEM equipment
  • Improved heat sink and charging capabilities
  • Higher grade of electric components

When using this regulator on 2016-2018 Polaris Sportsman 570 models, please pay close attention to the stator and regulator wiring harness routing. The OEM wire routing was very poor, and allowed the harness to rub against the motor, damaging the insulation and damaging the charging system. We recommend routing your stator/regulator wiring outside of the frame rail, and securing the harness to the frame with zip ties. This should prevent any future damage to the wiring harness.

Battery condition is extremely important. No voltage regulator can work correctly with a bad or weak battery. Always fully charge your battery before performing any charging system tests or replacing parts. If there is any doubt, have the battery load tested or replaced.

There were 2 different regulators used on 2017-2018 Polaris Sportsman 570 models. Please compare your original to our pictures. Our RMS020-100174 regulator will ONLY replace an original that looks EXACTLY the same. The other possible regulator is RM30421.

Why use Mosfet Enhanced technology?



Runs cooler

Runs much cooler than the traditional Shunt voltage regulator rectifier.


Saves gas

Less load on the stator, less work, less fuel is used and you save.


Regulated energy

The power charging your battery is steadier and smooth.

 


Extended battery life

Extends the battery’s life and cold cranking capacity.


More engine power

Removes stator load resulting in more engine power.


Optimized power

Optimize power delivery by switching the stator coils on or off.

RMSTATOR Enhanced technology=


With
 enhanced technologydesign

This product is an advanced design that lowers operating temperatures for extended longevity and better performance than the OEM part.

STOP BURNING YOUR REGULATOR RECTIFIER !
It is time to update or replace your voltage regulator with the advanced MOSFET type.

It runs cooler than all OEM diode style regulators. In addition, this rectifier has overheat protection, rather than burn up it will simply turn off for a while and cool off.

Write Your Own Review
You're reviewing:Kit Generator Stator + Mosfet Voltage Regulator Rectifier for Polaris Sportsman 325 ETX / 450 HO / 570 X2 2014-2020
Your Rating
Customers Also Viewed
Currently there is no product to display.