Stator for KTM 250 400 450 525 530 EXC XC-W SX MXC-G 1999-2011 | Husqvarna FS 450 | Husaberg FS 550 650 2004-2008
Battery condition is important. No stator can make up for a bad or weak battery. If in doubt charge your battery and have it load tested, or simply replace it. ALWAYS START WITH A FULLY CHARGED BATTERY !
- 2011 KTM 530 XC-W
- 2011 KTM 530 EXC-R
- 2011 KTM 530 EXC
- 2011 KTM 450 XC-W
- 2011 KTM 450 EXC
- 2011 KTM 400 EXC
- 2011 KTM 250 XCF-W
- 2010 KTM 530 XC-W
- 2010 KTM 530 EXC-R
- 2010 KTM 530 EXC
- 2010 KTM 450 XC-W
- 2010 KTM 450 EXC
- 2010 KTM 400 XC-W
- 2010 KTM 400 EXC
- 2010 KTM 250 XCF-W
- 2009 KTM 530 XC-W
- 2009 KTM 530 EXC-R
- 2009 KTM 530 EXC
- 2009 KTM 450 XC-W
- 2009 KTM 450 EXC
- 2009 KTM 400 XC-W
- 2009 KTM 400 EXC
- 2009 KTM 250 XCF-W
- 2008 KTM 530 XCR-W
- 2008 KTM 530 XC-W
- 2008 KTM 530 EXC-R
- 2008 KTM 450 XCR-W
- 2008 KTM 450 EXC-R
- 2008 KTM 450 EXC
- 2008 KTM 250 XC-F
- 2008 Husqvarna FS 450
- 2008 Husaberg FS 650 E
- 2008 Husaberg FS 650 C
- 2008 Husaberg FS 550 E
- 2007 KTM 525 XC
- 2007 KTM 525 EXC-G
- 2007 KTM 525 EXC
- 2007 KTM 450 XC-W
- 2007 KTM 450 EXC
- 2007 KTM 400 XC-W
- 2007 KTM 250 XC-F
- 2007 KTM 250 EXC-F
- 2007 Husqvarna FS 450
- 2007 Husaberg FS 650 E
- 2007 Husaberg FS 650 C
- 2007 Husaberg FS 550 E
- 2006 KTM 525 EXC
- 2006 KTM 450 EXC-G
- 2006 KTM 450 EXC
- 2006 KTM 400 EXC
- 2006 KTM 250 EXC Euro
- 2006 Husqvarna FS 450
- 2006 Husaberg FS 650 E
- 2006 Husaberg FS 650 C
- 2006 Husaberg FS 550 E
- 2005 KTM 525 MXC
- 2005 KTM 525 EXC
- 2005 KTM 450 MXC-G
- 2005 KTM 450 EXC-G
- 2005 KTM 450 EXC
- 2005 KTM 400 EXC
- 2005 KTM 250 EXC-G
- 2005 KTM 250 EXC Euro
- 2005 Husqvarna FS 450
- 2005 Husaberg FS 650 E
- 2005 Husaberg FS 650 C
- 2005 Husaberg FS 550 S
- 2005 Husaberg FS 550 E
- 2004 KTM 525
- 2004 KTM 450
- 2004 KTM 400
- 2004 KTM 250 EXC-G
- 2004 KTM 250 EXC Euro
- 2004 Husqvarna FS 450
- 2004 Husqvarna FE 450
- 2003 KTM 525
- 2003 KTM 450
- 2003 KTM 250 EXC-G
- 2003 KTM 250 EXC Euro
- 2002 KTM 520 SX
- 2002 KTM 520
- 2002 KTM 400
- 2002 KTM 250 SX
- 2001 KTM 520 SX
- 2001 KTM 520
- 2001 KTM 400
- 2000 KTM 520
- 2000 KTM 400
- 1999 KTM 520
- 1999 KTM 400
80039004000
59039104000
59039104200
Dimensions :
Interior diameter : 29 mm
Exterior diameter : 83 mm
Thickness : 13 mm
Length of wires stator to grommet : 60 mm
Length of wires grommet to plug : 490 mm
Other specifications :
Number of wires : 4
Number of plugs : 3
Number of pins : 4
Wire to wire resistance :
Alternator :White to Yellow = 0.5 ohms +-20%
Source: Black/Red to Red/White = 30 ohms +-20%
Before installing your new Generator Stator
- Check the AC output of the stator
- Replace any burned or corroded connectors on stator and regulator rectifier
- Check and repair any melted wiring
- Use hi-temp dielectric grease on all connectors
Our stator may use a different wire color code than your original.
All the wires are installed in the correct order; please do not change any of the wiring configurations.
This stator is designed as a direct plug-in replacement and should be used as such.
When bolting stator in, always use locking compound.
If our stator includes a pickup coil, always make sure the air gap is correct upon installation; we suggest as close as possible no less than 0.010".
Brand new aftermarket Generator Stator
- Direct replacement to your original unit
- Plug-and-play, direct fit, easy installation
- Highest grade of lamination materials
- Highest grade of copper winding, resistant to 200 degrees Celsius.
- Connector included
- Rubber grommet included
- All products shipped are tested
We have even included the opposite connector (main harness side) as we know these are often melted / corroded / defective and a major cause of repetitive electrical issues.
All item pictures are accurate; if in doubt, do not hesitate to compare our item to your original part.