Stator for Yamaha XT 225 Serow 1992-2000 XT225 | OEM Repl.# 4BE-81410-01-00 / 4BE-81410-00-00
Battery condition is extremely important. No stator can work correctly with a bad or weak battery. Always fully charge your battery before performing any charging system tests or replacing parts. If there is any doubt, have the battery load tested or replaced.
Interior diameter : 33 mm
Exterior diameter : 91 mm
Thickness : 17.5 mm
Length of wires stator to grommet : 170 mm
Length of wires grommet to plug : 380 mm
Other specifications :
Number of wires : 8
Number of plugs : 4
Number of pins : 8
Number of poles : 11
Wire to wire resistance :
Alternator : Between each White = 0.9 ohms +-20%
Source #1 : Red to Green = 739 ohms +-20%
Source #2 : Yellow to Black = 25.2 ohms +-20%
Before installing your new Stator
- Check the AC output of the stator
- Replace any burned or corroded connectors on stator and regulator rectifier
- Check and repair any melted wiring
- Use hi-temp dielectric grease on all connectors
Our CDI might have a different wire color code than your original part.
All the wires are installed in the correct order; please do not change any of the wiring configurations.
This stator is designed as a direct plug-in replacement and should be used as such.
When bolting stator in, always use locking compound.
If our stator includes a pickup coil, always make sure the air gap is correct upon installation; we suggest as close as possible but no less than 0.010".
Brand new aftermarket Stator
- Direct replacement to your original unit
- Plug-and-play, direct fit, easy installation
- Highest grade of lamination materials
- Highest grade of copper winding, resistant to 200 degrees Celsius
- Connectors included
- Rubber grommet included
- All products shipped are tested
We have even included the opposite connector (main harness side) as we know these are often melted / corroded / defective and a major cause of repetitive electrical issues.
All item pictures are accurate; if in doubt, do not hesitate to compare our item to your original part.