Stator for Yamaha Phazer 480 / ST / Mountain Lite Carb F/C 1997-1999

$USD 229.00
Availability: In stock

Battery condition is extremely important. No stator can work correctly with a bad or weak battery. Always fully charge your battery before performing any charging system tests or replacing parts. If there is any doubt, have the battery load tested or replaced.

Dimensions :
Interior diameter : 42mm
Exterior diameter : 104mm
Thickness : 17mm
Length of wires stator to grommet : 75mm
Length of wires grommet to plug : 200mm

Other specifications :
Number of wires : 5
Number of plugs : 0
Number of pins : 5

Wire to wire resistance :
Alternator : Yellow to White = 0.4ohms +/-20%
Alternator : Brown to Ground = 0.L
Source : Yellow/Black to Black = 1.4ohms +/-20%

Before installing your new stator

  • Check the AC output of the stator.
  • Replace any burned or corroded connectors on stator and regulator/rectifier
  • Check and repair any melted wiring.
  • Use hi-temp dielectric grease on all connectors

Our stator may use a different wire color code than your original.
All of the wires are installed in the correct order; please do not change any of the wiring configurations.
This stator is designed as a direct plug-in replacement and should be used as such.
When bolting stator in, always use locking compound.
If our stator includes a pickup coil, always make sure the air gap is correct upon installation; we suggest as close as possible no less than 0.010’’.

Brand new aftermarket stator

  • You must re-install your original connector (see picture).
  • Once your connector is re-installed, our part becomes a plug-and-play unit, direct fit, and very easy to install.
  • Highest grade lamination materials
  • Highest grade copper windings, resistant to 200 degrees Celsius.
  • Rubber grommet included
  • All products shipped are tested

We have even included the opposite connector (main harness side) as we know these are often melted/corroded/defective and a major cause for repetitive electrical issues.

All item pictures are accurate; if in doubt do not hesitate to compare our item to your original part.

Write Your Own Review
You're reviewing:Stator for Yamaha Phazer 480 / ST / Mountain Lite Carb F/C 1997-1999
Your Rating
Customers Also Viewed
Currently there is no product to display.