Voltage Regulator Rectifier for Arctic Cat 400 500 2x4 / 4x4 / Manual 2000 2001
If you have a 2002-2006 Polaris Sportsman 600 or 700 AC Ignition you might want to consider our DC conversion kit RM22957. This kit will give you more reliability and better spark.
This ignition controller is only for models built BEFORE 2/23/2003
Battery condition is extremely important. No voltage regulator can work correctly with a bad or weak battery. Always fully charge your battery before performing any charging system tests or replacing parts. If there is any doubt, have the battery load tested or replaced.
Width : 50mm
Length : 75mm
Fixation holes center to center : 60mm
Wires length: 250mm
Other specifications :
Number of plugs : 2
Number of pins : 5
- Check the AC output of the stator.
- Replace any burned or corroded connectors on stator and regulator/rectifier
- Check and repair any melted wiring.
- Use hi-temp dielectric grease on all connectors.
Brand new aftermarket voltage regulator rectifier
- Direct replacement to your original unit.
- Plug-and-play, direct fit, easy installation.
- No assembly required
- Higher grade of electric components.
- Improved heat sink and charging capabilities
- The quality exceeds the OEM equipment
- All products shipped are tested
*Arctic Cat has more than one regulator for some models. RM30007 replaces OEM 0530-006.
We have even included the opposite connector (main harness side) as we know these are often melted/corroded/defective and a major cause for repetitive electrical issues.
All item pictures are accurate, if in doubt do not hesitate and compare our item to your original part.